Comprehensive analysis of proteolysis during 8 months of ripening of high-cooked Old Saare cheese

We applied capillary electrophoresis, liquid chromatography coupled with tandem mass-spectrometry (MS/MS), and ultra-performance liquid chromatography to determine the composition of water-insoluble and water-soluble proteinaceous fractions of the cheese and to study in detail the degradation of caseins during 8 mo of ripening of Estonian high-temperature cooked hard cheese Old Saare. The application of high-resolution and high-accuracy MS/MS enabled identification of more than 3,000 small peptides, representing a fairly full casein peptidome containing peptides of 4 to 25 AA in length: 1,049 from β-casein (CN), 944 from αS1-CN, 813 from αS2-CN, and 234 from κ-CN. The majority of β-CN- and αS1-CN-derived peptides originated from the N-terminal parts of the molecule, f6-93 and f1-124, respectively; peptides from αS2-CN arose predominantly from the C-terminal end f100-162. At the beginning of ripening, we found a relatively high amount of peptides originating from the glycomacropeptide part of κ-CN, whereas peptides from para-κ-CN prevailed during the later stages of ripening of the cheese. The cleavage patterns of β-CN, αS2-CN, as well as αS1-CN, showed that primary proteolysis was started mainly by plasmin, although a low proteolytic activity of chymosin was also evident. Based on the analysis of cleavage sites, we observed a significant participation of proteolytic enzymes, including amino- and carboxypeptidases, of both mesophilic and thermophilic starter bacteria in further hydrolysis of oligopeptides during the ripening. Several new phosphopeptides were detected in the result of MS/MS data analysis. The profiles of the estimated concentrations of phosphopeptides revealed that those originating from β-CN and αS1-CN accumulated during cheese maturation. In contrast, we did not notice any generation of phosphopeptides from the highly phosphorylated part of αS2-CN, f25-80, presumably due to the inaccessibility of this region to the action of plasmin and chymosin. The analysis of cleavage sites and the combination of principal component and clustering analyses provided a characterization of the complex dynamics of formation and degradation of peptides during cheese maturation. We made an attempt to obtain a comprehensive picture of proteolysis during Old Saare cheese ripening on the basis of the detailed peptidomic data, including also the less abundant peptides determined by MS/MS, and complemented by the data on intact caseins and free AA and reported the results in the paper.