Article ID | Journal | Published Year | Pages | File Type |
---|---|---|---|---|
4527248 | Aquacultural Engineering | 2013 | 11 Pages |
Basic data describing the physical characteristics of fish fecal waste are important in the design of effective solid waste management in aquaculture, especially in land-based facilities such as recirculating aquacultural systems (RAS).This study describes the physical properties of feces from rainbow trout fed eight different commercially available and widely used diets in Germany. Additional data from an earlier but unpublished study pertaining to feces derived from two rather extreme all-vegetarian diets are also presented for consideration of the settling properties. The diets were tested on duplicate groups of 50 rainbow trout in a flow-through aquaculture system. The effects of the diets on the physical properties of fecal particles such as particle size distribution (PSD), modeled settling velocity and rheological character were examined and the effects of each diet on fish health, growth and feed utilization were determined. Specific growth rate (SGR) and feed conversion ratio (FCR) for the different diets ranged from 0.98% d−1 ± 0.012% d−1 to 1.39% d−1 ± 0.012% d−1 and 0.97 ± 0.017 to 1.61 ± 0.017 (mean ± S.E.), respectively. The density of presoaked feces was significantly lower than that of intestinal feces and ranged from 1.01013 ± 0.00692 g cm−3 to 1.04547 ± 0.00692 g cm−3 (mean ± S.E.). Stability data were in the range from 390.12 ± 29.4 Pa to 1214.79 ± 29.0 Pa for elastic modulus and from 62.12 ± 6.1 Pa s to 232.68 ± 6.0 Pa s for dynamic viscosity. Based on the stability and PSD data theoretical efficiencies for removal of fecal waste using a drum filter showed remarkable variation, ranging from 82.5 to 95.9% (60 μm gauze). Based on the same data, theoretical removal by a sedimentation basin with routinely using overflow rates of 0.057 cm s−1 to 0.394 cm s−1 ranged from 62.8 to 93.8%. Both fecal density and PSD have an exponential impact on settling performance. Increasing fecal density improves the removal efficiency of a sedimentation basin by about 20%, however sedimentation was seen to be a less robust and efficient removal technique than drum filtration. Sedimentation systems also experience additional problems with respect to leaching. Turbulence that was mimicked in this study reflects to an optimal fish farm, which means disintegrating effects are mainly caused by fish motion. If disintegrating units e.g. pumps are used, which are known to promote further particle breakdown the effects would be amplified.The results demonstrate the central importance of density of suspended solids in defining removal efficiencies and suggest that manipulation of fecal density might offer a new and effective means of managing and optimizing waste output from aquaculture operations. This study describes the basic properties of fecal wastes generated by commercial diets and can be used as a basis for further research.
► We examine range of fecal properties caused by commercial and vegetarian diets. ► We model removal efficiency of 8 commercial diets and 2 all-vegetarian diets for either a drum filter and a sedimentation basin. ► Fecal density and particle size distribution have an exponential effect on settling properties. ► Removal efficiency can be improved by up to 20% when density is increased. ► Microscreening is more robust to variations.