Significant Reduction of Laboratory Specimen Labeling Errors by Implementation of an Electronic Ordering System Paired With a Bar-Code Specimen Labeling Process

Study objectiveWe measure the rate of emergency department (ED) specimen processing error reduction after implementation of an electronic physician order entry system paired with a bar-coded specimen labeling process.MethodsA cohort pre- and postintervention study was conducted in the ED during a 61-month period ending September 2008 in a large urban teaching hospital. Historically, laboratory order and requisition processing was done by hand. Interventions included implementing an ED-specific electronic documentation and information system, which included physician order entry with patient verification through bar-coded wristbands and bar-coded specimen labels. The main outcome measure was processing error rate, defined as unlabeled/mislabeled/wrong patient specimen or requisition. Pre- and postimplementation data were tabulated monthly and compared in aggregate by χ2 test. The contribution of ED error to total institution specimen error was also calculated.ResultsOf the 724,465 specimens collected preintervention, 3,007 (0.42%) were recorded as errors versus 379 errors (0.11%) of 334,039 specimens collected postintervention, which represents a 74% relative and 0.31% absolute decrease (95% confidence interval 0.28% to 0.32%). The proportion of institutional errors contributed by the ED was reduced from 20.4% to 11.4%, a 44% relative and 9.0% absolute reduction (95% confidence interval 7.7% to 10.3%). Subanalysis revealed that the majority of continued errors occur when the physician order entry/bar-code system could not be used (eg, blood bank or surgical pathology specimens).ConclusionCombining an electronic physician order entry with bar-coded patient verification and electronic documentation and information system–generated specimen labels can significantly reduce ED specimen-related errors, with sizable influence on institutional specimen-related errors. Continued use of hand labeling and processing for special specimens appears inadvisable, though the cost-effectiveness of this intervention has not been established.