کد مقاله | کد نشریه | سال انتشار | مقاله انگلیسی | نسخه تمام متن |
---|---|---|---|---|
42792 | 45941 | 2009 | 13 صفحه PDF | دانلود رایگان |
Mesostructured Al-MCM-41 materials (referred as CSAn, where n = Si/Al molar ratio = 50, 30 and 10, respectively) and 12-tungstophosphoric acid promoted Pt/Al-MCM-41 catalysts were investigated by a variety of spectroscopic techniques. Aluminum ions were distributed within the resultant solid having 4, 5 or 6-coordination, in different proportion, which correlate with the formation of Brönsted acidity. Grafting the H3PW12O40 heteropolyacid (referred as HPW) on the Al-MCM-41 solids not only noticeably enhanced, by 2–3 times, the number of Brönsted acid sites, but also greatly improved the acidity strength, with respect to that of the bare host. The primary structure of the Keggin units of the supported heteropolyacid was largely preserved after calcination at 350 °C; however, small parts of the Keggin units were strongly distorted or deformed due to the strong interaction between the heteropolyanions and the hydroxyl groups of the support. Catalytic evaluation confirmed that 1 wt.%Pt/25 wt.%HPW/Al-MCM-41 (denoted as Pt/HPW/CSAn) catalysts were very active for n-heptane isomerization in the presence of hydrogen under an atmospheric pressure condition. High yield of multibranched isoheptanes was produced, which was dependent on the pore diameter and the Brönsted acidity of the catalysts. The molar ratio of multibranched to monobranched isoheptanes is much higher than that reported in the literature under similar reaction conditions using zeolite-containing catalysts, showing the potential of producing high octane number fuel through the approach of n-heptane hydroisomerization by using our novel mesostructured catalysts.
Grafting 12-tungstophosphoric acid on Al-MCM-41 could greatly enhance both the number and strength of Brönsted acidity. In the n-heptane hydroisomerization at an atmospheric pressure condition, high molar ratio of multibranched to monbranched isoheptanes was obtained over the heteropolyacid promoted Pt/H3PW12O40/Al-MCM-41 catalysts. The unique selectivity of multibranched isoheptanes was related to ordered mesopore structure and strong surface acidity.Figure optionsDownload as PowerPoint slide
Journal: Applied Catalysis A: General - Volume 357, Issue 2, 15 April 2009, Pages 223–235