Effect of sodium, potassium, magnesium, and calcium salt cations on pH, proteolysis, organic acids, and microbial populations during storage of full-fat Cheddar cheese1

Sodium reduction in cheese can assist in reducing overall dietary Na intake, yet saltiness is an important aspect of cheese flavor. Our objective was to evaluate the effect of partial substitution of Na with K on survival of lactic acid bacteria (LAB) and nonstarter LAB (NSLAB), pH, organic acid production, and extent of proteolysis as water-soluble nitrogen (WSN) and protein profiles using urea-PAGE, in Cheddar cheese during 9 mo of storage. Seven Cheddar cheeses with molar salt contents equivalent to 1.7% salt but with different ratios of Na, K, Ca, and Mg cations were manufactured as well as a low-salt cheese with 0.7% salt. The 1.7% salt cheeses had a mean composition of 352 g of moisture/kg, 259 g of protein/kg and 50% fat-on-dry-basis, and 17.5 g of salt/kg (measured as Cl−). After salting, a faster initial decrease in cheese pH occurred with low salt or K substitution and it remained lower throughout storage. No difference in intact casein levels or percentage WSN levels between the various cheeses was observed, with the percentage WSN increasing from 5% at d 1 to 25% at 9 mo. A greater decrease in intact αs1-casein than β-casein was detected, and the ratio of αs1-casein (f121-199) to αs1-casein could be used as an index of ripening. Typical changes in bacteria microflora occurred during storage, with lactococci decreasing gradually and NSLAB increasing. Lowering the Na content, even with K replacement, extended the crossover time when NSLAB became dominant. The crossover time was 4.5 mo for the control cheese and was delayed to 5.2, 6.0, 6.1, and 6.2 mo for cheeses with 10, 25, 50, and 75% K substitution. Including 10% Mg or Ca, along with 40% K, further increased crossover time, whereas the longest crossover time (7.3 mo) was for low-salt cheese. By 9 mo, NSLAB levels in all cheeses had increased from initial levels of ≤102 to approximately 106 cfu/g. Lactococci remained at 106 cfu/g in the low-salt cheese even after 9 mo of storage. The propionic acid concentration in the cheese increased when NSLAB numbers were high. Few other trends in organic acid concentration were observed as a function of Na content.