Dose-dependent clearance kinetics of intratracheally administered titanium dioxide nanoparticles in rat lung

AEROSIL® P25 titanium dioxide (TiO2) nanoparticles dispersed in 0.2% disodium phosphate solution were intratracheally administered to male F344 rats at doses of 0 (control), 0.375, 0.75, 1.5, 3.0, and 6.0 mg/kg. The rats were sacrificed under anesthesia at 1 day, 3 days, 7 days, 4 weeks, 13 weeks, and 26 weeks after administration. Ti levels in various pulmonary and extrapulmonary organs were determined using sensitive inductively coupled plasma sector field mass spectrometry. One day after administration, the lungs contained 62-83% of TiO2 administered dose. Twenty-six weeks after administration, the lungs retained 6.6-8.9% of the TiO2 administered at the 0.375, 0.75, and 1.5 mg/kg doses, and 13% and 31% of the TiO2 administered at the 3.0 and 6.0 mg/kg doses, respectively. The pulmonary clearance rate constants from compartment 1, k1, were estimated using a 2-compartment model and were found to be higher for the 0.375 and 0.75 mg/kg doses of TiO2 (0.030/day for both) than for TiO2 doses of 1.5-6.0 mg/kg (0.014-0.022/day). The translocation rate constants from compartment 1 to 2, k12, were estimated to be 0.015 and 0.018/day for the 0.375 and 0.75 mg/kg doses, and 0.0025-0.0092/day for doses of 1.5-6.0 mg/kg. The pulmonary clearance rate constants from compartment 2, k2, were estimated to be 0.0086 and 0.0093/day for doses of 0.375 and 0.75 mg/kg, and 0-0.00082/day for 1.5-6.0 mg/kg doses. Translocation of TiO2 from the lungs to the thoracic lymph nodes increased in a time- and dose-dependent manner, accounting for 0.10-3.4% of the administered dose at 26 weeks. The measured thoracic lymph node burdens were a much better fit to the thoracic lymph node burdens estimated assuming translocation from compartment 1 to the thoracic lymph nodes, rather than those estimated assuming translocation from compartment 2 to the thoracic lymph nodes. The translocation rate constants from the lungs to the thoracic lymph nodes, kLung→Lym, were 0.000037-0.00081/day, and these also increased with increasing doses of TiO2. Although a small amount of TiO2 had translocated to the liver by 3 days after the administration (0.0023-0.012% of the highest dose administered, 6.0 mg/kg), translocation to the other extrapulmonary organs was not detected.