کد مقاله | کد نشریه | سال انتشار | مقاله انگلیسی | نسخه تمام متن |
---|---|---|---|---|
6355590 | 1315052 | 2012 | 10 صفحه PDF | دانلود رایگان |
This work reports the effect of pressure on the steam/oxygen gasification at 1000 °C of the char derived from low temperature-pressure distillation of granulated scrap tyres (GST). The study was based on the analysis of gas production, carbon conversion, cold gas efficiency and the high heating value (HHV) of the product. For comparison, similar analyses were carried out for the gasification of coals with different rank.In spite of the relatively high ash (â12 wt.%) and sulphur (â3 wt.%) contents, the char produced in GST distillation can be regarded as a reasonable solid fuel with a calorific value of 34 MJ kgâ1. The combustion properties of the char (EA â 50 kJ molâ1), its temperature of self-heating (â264 °C), ignition temperature (â459 °C) and burn-out temperature (â676 °C) were found to be similar to those of a semi-anthracite.It is observed that the yield, H2 and CO contents and HHV of the syngas produced from char gasification increase with pressure. At 0.1 MPa, 4.6 Nm3 kgcharâ1 of syngas was produced, containing 28% v/v of H2 and CO and with a HHV around 3.7 MJ Nmâ3. At 1.5 MPa, the syngas yield achieved 4.9 Nm3 kgcharâ1 with 30% v/v of H2-CO and HHV of 4.1 MJ Nmâ3. Carbon conversion significantly increased from 87% at 0.1 MPa to 98% at 1.5 MPa.It is shown that the char derived from distillation of granulated scrap tyres can be further gasified to render a gas of considerable heating value, especially when gasification proceeds at high pressure.
⺠Granulated scrap tyres are distilled at low temperature. ⺠The as-obtained char fraction is gasified at 1000 °C. ⺠The syngas that may be used in a gas turbine. ⺠The gasification of this char is similar to those for semi-anthracite coal.
Journal: Waste Management - Volume 32, Issue 4, April 2012, Pages 743-752