Effect of crude oil ageing on low salinity and low salinity surfactant flooding

Injection of brine with lower salinity than the connate brine has proven to give a moderate increase in oil recovery in sandstones. Recent research has shown that this process will significantly benefit from introducing surfactant optimised for low salinity environment.The mechanisms underlying increased recovery by low salinity brine injection are not yet fully understood. However, research to date suggests that they are related to complex crude oil/brine/rock interactions. With this in mind, the present paper investigates primarily how the extent of oil recovery from Berea sandstones subjected to long term exposure of crude oil is influenced by (1) low salinity water injection and (2) combined process low salinity water injection with surfactant flooding.Core displacement tests were conducted on four Berea cores (30 cm), two in a natural state and two that had been subject to extensive crude oil ageing at high temperature. Results obtained from different flooding steps are discussed in terms of oil recovery and effluent properties including turbidity, pH- and ion analysis (Na+, Mg2+, Ca2+). The results effectively illustrate that oil recoveries from the aged cores are higher during both low salinity water injection and low salinity water injection combined with surfactant flooding. An assessment of how tertiary oil recovery in aged and unaged cores varies with surfactant concentration is also presented.Effluent ion analysis from low salinity water floods showed that Mg2+ ions were strongly retained in the aged core while Ca2+ ions were being produced from both aged and unaged cores. The latter was attributed mainly to calcite dissolution. Results obtained from pressure profiles, effluent ion analysis and turbidity tests suggest higher production and elution of fine particles from the unaged core.

► Oil recovery is higher from aged cores during both processes.
► Mg2+ was retained in the aged core while Ca2+ was being produced from both cores.
► Increased production of Ca2+ is attributed to calcite dissolution.
► Unaged cores show increased fines migration upon low salinity water injection.