Determination of open-circuit potentials at gas/electrode/YSZ boundary versus molten carbonate reference electrode at medium temperatures: I. Potentials of Au and Pt in O2 and H2 + H2O atmospheres

A double gas concentration cell as combination of the cell with the yttria stabilized zirconia (YSZ) electrolyte and the cell with molten Li2CO3 + Na2CO3 eutectics is proposed as an alternative cell system with a standard reference electrode for measurements of the open-circuit potential (OCP) values of electrodes in oxygen concentration cell with the yttria stabilized zirconia (YSZ) electrolyte. In this double-cell one electrode is common for the two cells and the reference electrode is the standard molten carbonate half-cell with 0.33O2 + 0.67CO2 atmosphere. This reference electrode should enable the monitoring of OCP and overpotential values in polarization studies in the three-electrodes configuration. If the possible reaction between the solid YSZ and liquid molten carbonates electrolyte is very slow, the measured values of the open-circuit-voltage (OCV) of this cell may be considered equal to the respective reversible electromotive forces (EMF). Very good resistance of the smooth YSZ products to the corrosion in highly dehydrated Li/Na molten carbonates has been shown in experiments lasting few 1000 h. Hence, the consistency of OCV values with the respective EMF values have been tested at various partial pressures of CO2 and O2 in the gas mixtures above the molten carbonate electrolyte and at various partial pressures of O2 + Ar or H2 + H2O gas mixtures at the Au or Pt electrodes/YSZ interface. The results have shown the reliability of the double-cell in determination of the open-circuit potentials (OCP) of gas electrodes at the YSZ surface as measured versus the reference electrode with molten carbonate electrolyte. The consistency of OCP and EMF values has been shown satisfying and enhances to use the proposed double-cell in further investigations of OCP and overpotential values at TPB of electrode/YSZ/mixture of reacting gases. At high differences of O2 partial pressures on both sides of the YSZ membrane some permeation of this gas through the YSZ membrane has been observed. Probably, this effect has an electrochemical character.