Sterilization by gamma radiation impairs the tensile fatigue life of cortical bone by two orders of magnitude

Cortical bone grafts are utilized frequently for skeletal reconstruction, spinal fusion and tumor surgery. Due to its efficacy and convenience terminal sterilization by gamma radiation is often essential to minimize disease transmission and infection. However, the impairment in the material properties of bone tissue secondary to gamma radiation sterilization is a concern since the mechanical functionality of a bone graft is of primary importance. While the extent of this impairment is well investigated for monotonic loading conditions, there does not seem to exist any information on the effects of gamma radiation sterilization on cortical bone's fatigue properties, the physiologically relevant mode of loading. In this study we investigated the degradation in the high-cycle and low-cycle tensile fatigue lives of cortical bone tissue secondary to gamma radiation sterilization at a dose of 36.4 kGy which approximately falls in the higher end of the standard dose range used in tissue banking. The high-cycle and the low-cycle fatigue tests were conducted under load control at initial strain levels of 0.2% and 0.4%, respectively. Monotonic tensile tests were also conducted to compare the impairment of fatigue properties with the impairment of monotonic properties. Results demonstrated that the impairment in both the high-cycle and the low-cycle fatigue lives were two orders of magnitude following sterilization, a change much more pronounced than that observed for monotonic loading. In conclusion, the results suggest that the impairment of the mechanical function of gamma radiation sterilized allografts is even worse in fatigue than monotonically. Therefore, grafts should be designed to minimize functional strains and avoid stress raisers to prevent premature fatigue failures.