Planar solid phase extraction clean-up for pesticide residue analysis in tea by liquid chromatography–mass spectrometry

Efficient clean-up is indispensable for preventing matrix effects in multi-residue analysis of pesticides in food by liquid and gas chromatography (LC and GC) coupled to mass spectrometry (MS). High-throughput planar solid phase extraction (HTpSPE) was recently introduced as a new clean-up concept in residue analysis of pesticides in fruit and vegetables (C. Oellig, W. Schwack, 2011 [45]). Thin-layer chromatography (TLC) was used to completely separate pesticides from matrix compounds and to focus them into a sharp zone, followed by extraction of the target zone by the TLC–MS interface. As rather challenging matrices, tea samples were chosen in this study. Besides chlorophylls and polyphenols, high amount of caffeine is co-extracted resulting in strong matrix effects both in LC–MS and GC–MS. The former HTpSPE procedure was adapted to initial extracts of green and black tea resulting in colorless extracts nearly free of matrix effects and interferences, as shown for seven chemically representative pesticides (acetamiprid, penconazole, azoxystrobin, chlorpyrifos, pirimicarb, fenarimol, and mepanipyrim). LC–MS/MS calibration curves obtained in the range of 0.002–0.5 mg/kg from matrix-matched standards and solvent standards were nearly identical and demonstrated the effectiveness of clean-up by HTpSPE. Mean recoveries determined by LC–MS/MS against solvent standards at spiking levels of 0.01 and 0.1 mg/kg ranged between 72 and 114% with relative standard deviations (RSDs) of 0.7–4.7% (n = 4), while LC–MS measurements of tea samples spiked at 1 mg/kg provided recoveries of 81–104% with RSDs of 1.2–4.9% (n = 6). Using LC–MS/MS, the method showed high sensitivity with signal-to-noise ratios >10 for concentrations below 0.002 mg/kg. HTpSPE of one sample was done in a few minutes, while numerous samples were cleaned in parallel at minimal costs with very low sample and solvent consumption.

► A new clean-up concept for pesticide residue analysis in tea by LC–MS is introduced.
► Planar solid phase extraction was proven to be the highly efficient clean-up method.
► Nearly matrix-free tea extracts generally avoided matrix effects in LC–MS(/MS).
► Applying pure solvent standards, method validation showed impressive results.