Waste activated sludge fermentation: Effect of solids retention time and biomass concentration

Laboratory scale, room temperature, semi-continuous reactors were set-up to investigate the effect of solids retention time (SRT, equal to HRT hydraulic retention time) and biomass concentration on generation of volatile fatty acids (VFA) from the non-methanogenic fermentation of waste activated sludge (WAS) originating from an enhanced biological phosphorus removal process. It was found that VFA yields increased with SRT. At the longest SRT (10 d), improved biomass degradation resulted in the highest soluble to total COD ratio and the highest VFA yield from the influent COD (0.14 g VFA-COD/g TCOD). It was also observed that under the same SRT, VFA yields increased when the biomass concentration decreased. At a 10 d SRT the VFA yield increased by 46%, when the biomass concentration decreased from 13 g/L to 4.8 g/L. Relatively high nutrient release was observed during fermentation. The average phosphorus release was 17.3 mg PO4-P/g TCOD and nitrogen release was 25.8 mg NH4-N/g TCOD.